Certain peculiarities of the influence of antimony on electrolysis parameters of zinc
https://doi.org/10.17073/0021-3438-2015-5-20-24
Abstract
The influence of antimony ions (Sb3+) in a concentration range of 0,001–0,200 mg/L on the current yield of zinc during the electrolysis of sulfate solutions is investigated. It is established that antimony, in contrast to germanium and tin, promotes an increase in current yield of zinc under definite conditions. This is caused by the fact that the alloy of zinc with antimony, which possesses the potential more positive compared with zinc, is deposited on separate cathode segments, due to which, the discharge of zinc ions proceeds in the depolarization mode with a higher current yield. A decrease in the current yield of zinc with the fraction of antimony higher than 0,2 mg/L is associated with the prevalent effect of galvanic pairs of antimony with zinc over the electrolysis with the depolarization. It is established that antimony enhances the negative effect of cobalt on the current yield of zinc due to the formation of the alloy of cobalt with antimony, on which the isolation overvoltage of hydrogen is lower than on zinc.
About the Authors
V. M. Alkatsev
Северо-Кавказский горно-металлургический институт (СКГМИ)
(государственный технологический университет), г. Владикавказ
Russian Federation
Russian Federation
M. I. Alkatsev
Северо-Кавказский горно-металлургический институт (СКГМИ)
(государственный технологический университет), г. Владикавказ
Russian Federation
Russian Federation
I. V. Darchiev
Северо-Кавказский горно-металлургический институт (СКГМИ)
(государственный технологический университет), г. Владикавказ
Russian Federation
Russian Federation
V. A. Lin’kov
Северо-Кавказский горно-металлургический институт (СКГМИ) (государственный технологический университет), г. Владикавказ
Russian Federation
Russian Federation
References
1. Loskutov F.M. Metallurgiya svintsa i tsinka [Metallurgy of lead and zinc]. Moscow: Metallurgizdat, 1956.
2. Lakernik M.M., Pakhomova T.N. Metallurgiya tsinka i kadmiya [Metallurgy of lead and kadmium]. Moscow: Metallurgiya, 1969.
3. Baimakov Yu.V., Zhurin A.I. Elektroliz v gidrometallurgii [Electrolysis in hydrometallurgy]. Moscow: Metallurgiya, 1977.
4. Snurnikov A.P. Gidrometallurgya tsinka [Hydrometallurgy of zinc]. Moscow: Metallurgiya, 1981.
5. Shivrin G.N. Metallurgiya svintsa i tsinka [Metallurgy of lead and zinc]. Moscow: Metallurgia, 1982.
6. Kazanbaev L.A., Kubasov V.L., Kolesnikov A.B. Gidrometallurgya tsinka [Hydrometallurgy of zinc (purification and electrolysis)]. Moscow: Ruda i metally, 2006.
7. Klyayyn S.E., Kozlov P.A., Naboichenko S.S. Izvlechenie tsinka iz rudnogo syr’ya [Extraction of zinc from ore raw materials, purification and electrolysis]. Ekaterinburg: UPI, 2009.
8. Alkatsev V.M., Alkatsev M.I., Lin’kov V.A., Darchiev I.V. Vliyanie primesei v elektrolite (na primere olova, germaniya i sur’my) na vykhod po toku tsinka [Influence of impurities in electrolyte on current efficiency of zinc]. Izvestiya vuzov. Tsvetnaya metallurgiya. 2014. No. 3. P. 20—24.
9. Alkatsev V.M., Alkatsev M.I., Lin’kov V.A., Darchiev I.V. Influence of impurities in electrolyte (tin, germanium and antimony) on current efficiency within electro-winning of zinc. Russ. J. Non-Ferr. Met. 2014. Vol. 55. No. 4. Р. 327— 330.
10. Spravochnik po electrohimii. Ed. A.M. Sukhotin [Handbook of Electrochemistry. Electrodeposition of alloys]. Leningrad: Khimiya, 1981.
11. Grilikhes S.Ya., Tikhonov K.I. Elektroliticheskie i khimicheskie pokrytiya. Teoriya i praktika [Electrolytic and chemical coatings. Theory and practice. Leningrad: Khimiya, 1990.
12. Bakhchisarayts’yan N.G., Burkat G.K., Varypaev V.N. Praktikum po prikladnoy elektrokhimii [Workshop on applied electrochemistry]. Leningrad: Khimiya, 1990.
13. Kiparisov S.S., Libenson G.A. Poroshkovaya metallurgiya [Powder metallurgy]. Moscow: Metallurgiya, 1980.
14. Alkatsev V.M., Enaldiev V.M., Alkatsev M.I. Sistemny analiz vliyaniya razlichnykh faktorov na pokazateli elektroliza sul’fatnykh tzinkovykh rastvorov [System analysis of the impact of various factors on the electrolysis of zinc sulfate solutious]. Izvestiya vuzov. Tsvetnaya metallurgiya. 1988. No. 5. P. 46—49.
15. Biegler T.I., Frazer E.I. Effect of impurities on coulombic efficiency in zinc electro-winning. Res. Rept. CSIRO. Div. Miner Chem. 1984. Р. 96.
16. Fosnacht D.R., O’ Keefe T.J. The effects of certain impurities and their interactions on zinc electro-winning. Met. Trans. 1983. Vol. 14. No. 1—4. Р. 645—655.
Review
For citations:
Alkatsev V.M., Alkatsev M.I., Darchiev I.V., Lin’kov V.A. Certain peculiarities of the influence of antimony on electrolysis parameters of zinc. Izvestiya. Non-Ferrous Metallurgy. 2015;(5):20-24. (In Russ.) https://doi.org/10.17073/0021-3438-2015-5-20-24
Views:
701
Email this article 